Clutch Lever Free Play — — — Clutch 2. Battery 12 V 10 Ah 5. Hold the container level, push down to break the seals of all six cells. Run the manuual brake light switch lead through the hole on frame. If there is continuity, the harness has a short circuit to ground, and it must be repaired or re- placed. Air Cleaner Housing 2.
|Published (Last):||21 July 2017|
|PDF File Size:||13.81 Mb|
|ePub File Size:||1.10 Mb|
|Price:||Free* [*Free Regsitration Required]|
Page Drive Chain Slack Adjustment WARNING A chain that breaks or jumps off the sprockets could snag on the engine sprocket or lock the rear wheel, se- verely damaging the motorcycle and causing it to go out of control.
Page Rear Shock Absorber A. Cotter Pin B. Page Coolant Close the fuel tank cap. Check for any leaks. Page Idle Speed Adjustment Stop the engine, then wait sev- eral minutes until the oil settles. The oil level should come up between the up- per and lower level lines next to the gauge. If the free play is incorrect, adjust the throttle cables.
Throttle Grip Free Play: 2 a 3 mm 0. Page Rear Brake Light Switch 0. This is a 50 mm 2 in. For other than US and Canadian models Always use a clean cloth. Oil contamination from hands or dirty rags can reduce bulb life or cause the bulb to explode. Check tightness of all fasteners that are in the table before retail delivery. Also check to see that each cotter pin or circlip is in place.
Page 29 Fastener Steering 1 Handlebar clamp bolt Brake 2 Front master cylinder clamp bolt 3 Front brake bleed valve Left and Right 4 Front caliper mounting bolt Left and Right 5 Rear master cylinder mounting bolt 6 Rear brake bleed valve 7 Rear caliper mounting bolt Wheel 8 Front axle Page Standard Torque Table 7.
Control Cables: Throttle cables must work without binding in any steering position. This manual is also suitable for:.
2012 Kawasaki Ninja 650 — Owner's Manual
Kawasaki NINJA 650R Assembly & Preparation Manual
Kawasaki Ninja 650R Service Manual
Kawasaki Ninja 650R 2012 Full Service Repair Manual